Contact and Occupational Dermatitis

Last updated by Peer reviewed by Dr Hayley Willacy, FRCGP
Last updated Meets Patient’s editorial guidelines

Added to Saved items
This article is for Medical Professionals

Professional Reference articles are designed for health professionals to use. They are written by UK doctors and based on research evidence, UK and European Guidelines. You may find the Contact Dermatitis article more useful, or one of our other health articles.

Read COVID-19 guidance from NICE

Treatment of almost all medical conditions has been affected by the COVID-19 pandemic. NICE has issued rapid update guidelines in relation to many of these. This guidance is changing frequently. Please visit https://www.nice.org.uk/covid-19 to see if there is temporary guidance issued by NICE in relation to the management of this condition, which may vary from the information given below.

Contact dermatitis describes an inflammatory process of the skin that occurs in response to contact with exogenous substances and involves pruritic and erythematous patches.

Contact dermatitis may be classified into the following reaction types:

  • Subjective irritancy: idiosyncratic stinging and smarting reactions occur within minutes of contact, usually on the face, in the absence of visible changes. Cosmetic or sunscreen constituents are common precipitants.
  • Acute irritant contact dermatitis: often the result of a single overwhelming exposure or a few brief exposures to strong irritants or caustic agents.
  • Chronic (cumulative) irritant contact dermatitis: occurs following repetitive exposure to weaker irritants that may be either ‘wet’, such as detergents, organic solvents, soaps, weak acids and alkalis, or ‘dry’, such as low-humidity air, heat, powders, paper, cardboard and dusts.
  • Allergic contact dermatitis: this involves sensitisation of the immune system to a specific allergen or allergens with resulting dermatitis or exacerbation of pre-existing dermatitis.
  • Phototoxic, photoallergic and photoaggravated contact dermatitis: some allergens are also photoallergens.
  • Systemic contact dermatitis (systemic allergic dermatitis): seen after the systemic administration of a chemical, usually a drug, to which topical sensitisation has occurred previously.
  • Protein contact dermatitis: repetitive handling of proteins, usually foods, results initially in immediate urticarial symptoms and signs, but later progresses to a dermatitic reaction. Prick and radioallergosorbent tests to the offending protein allergen are positive, but patch tests are negative. The proteins may be vegetables (potato, garlic), meats, fish (in food handlers), flour, enzymes (in bakers and pharmaceutical manufacture), and animal dander and fluids (in veterinarians and abattoir workers).

Occupational dermatitis is the most common of a number of skin diseases caused by exposure to a physical, chemical or biological agent in the workplace. Occupational skin disease is a disorder wholly or partially due to a person's occupation.

Health and safety regulations have reduced the risk of acquiring such conditions and, if they occur and are disabling, the employee may be entitled to claim for compensation as for industrial injury.

Occupational contact dermatitis is often a result of combined allergic, irritant, and endogenous factors. Potential causes can be split into three main groups: workplace materials, personal protective equipment, and skin care.

  • The prevalence of dermatitis in the UK is estimated to be about 20%.
  • 4-7% of all dermatological consultations are for contact dermatitis.
  • Women are more commonly affected than men.
  • The hands are most commonly affected (75% of all cases and as much as 90% of cases of occupational contact dermatitis).
  • Prevalence in children is lower, but is increasing.[5, 6]

For occupational contact dermatitis, the highest risk occupations include:[7]

  • Healthcare.
  • Engineering.
  • Food production.
  • Cleaning.
  • Hair and beauty.
  • Petrochemical Industry.
  • Manufacture of hard metal.
  • Foundries.
  • Plating.
  • Construction.
  • Florists.
  • Horticulture.
    Agriculture.

Broadly there are two types of contact dermatitis, which may co-exist:

  • Allergic contact dermatitis - a type IV delayed hypersensitivity reaction. It occurs after sensitisation and subsequent re-exposure to an allergen.
  • Irritant contact dermatitis - an inflammatory response that occurs after damage to the skin, usually by chemicals. This is not an allergy and can occur in any individual significantly exposed to an irritant. This may be acute or chronic/cumulative.

Most insults can be classified as chemical, biological or physical in origin. Contact with allergens can arise from immersion of usually the hands but sometimes the legs. It may arise from direct handling of contaminated substances or from workbenches, tools or clothing. Splashing may occur or dust in the air, such as cement dust.

Common irritants

  • Water - especially if hard, chalky or heavily chlorinated.
  • Detergents and soaps.
  • Solvents and abrasives.
  • Machining oils.
  • Acids and alkalis, including cement.
  • Reducing agents and oxidising agents, including sodium hypochlorite.
  • Powders, dust, and soil.
  • Plants - for example, ranunculus, spurge, boraginaceae, mustards.

Common allergens

  • Cosmetics - particularly fragrances, hair dyes, preservatives, and nail varnish resins.
  • Metals - particularly nickel and cobalt in jewellery, chromate in cement.
  • Topical medications, including rare allergy to topical corticosteroids.
  • Rubber additives.
  • Textiles- particularly from dyes and formaldehyde resins.
  • Epoxy resin adhesives.
  • Acrylic or acrylates and formaldehyde present in adhesives and plastic resins.
  • Plants - chrysanthemum, sunflowers, daffodils, tulips, and primula are the most common.

Many other agents have been found to produce contact dermatitis, including animals, fungi, bacteria, insects, foods and preservatives, heat, cold, variations in humidity, as well as various wavelengths of light and ionising radiation.

The presentation and pattern of skin change may give some indication of the likely irritant. Hands are the most frequently affected with direct contact. Chemicals on clothing may produce changes in axillae, groins and feet.

Dust irritants are most likely to cause problems in areas where the dust might collect such as the collar line, belt line and sock line or in flexural areas. Irritants in vapour or mist form are most likely to affect the face and neck. Irritant contact dermatitis and allergic dermatitis can produce similar changes in the skin and may present with:

  • Redness of skin.
  • Vesicles or papules on an affected area.
  • Crusting and scaling of skin.
  • Itching of an affected area.
  • Fissures (chronic exposure).
  • Hyperpigmentation (chronic exposure).
  • Pain or burning sensation from an affected area

Contact and allergic dermatitis may, however, have some differences in presentation:

Typical features of irritant contact dermatitisTypical features of allergic contact dermatitis
Burning, stinging and soreness are predominantRedness, itch and scaling are predominant
Usual onset within 48 hours; may be immediateDelayed onset
Rash only in areas of skin exposed to the irritantRash may be in areas which have not been in contact with and allergen. However, the distribution of the rash is still helpful in ascertaining the likely allergen
Resolution occurs quickly after removal of the irritant - typically, within four daysResolution may take longer than irritant contact dermatitis, with or without treatment
Commonly associated with atopic eczema, which increases the riskLess strong association with atopic eczema
Exposure to friction, soap, detergents, solvents, or wet work make diagnosis likely

Assessment should include a full occupational history:[8]

  • Job.
  • Materials involved (with particular regard to the more common causes mentioned above).
  • Amount of exposure, duration and frequency of contact.
  • Location of rash, anatomical distribution.
  • Timing of rash with relation to work - time from contact to first presentation, whether skin clears between exposure times.

In many cases, no investigations will be required and the diagnosis is made on the clinical findings and history.

Some patients need to be referred to a specialist clinic for patch testing, which is the gold standard investigation for this condition. Combined guidelines from the British Association of Dermatologists, Occupational Health Clinical Effectiveness Unit and the British Occupational Health Research Foundation advise that all those with occupational contact dermatitis be referred to a specialist clinic for patch and/or prick testing.[1, 8]

Other indications for patch tests include severe or recurring distressing symptoms despite adequate treatment with topical corticosteroids and suspicion of contact dermatitis without clear history of exposure.

Occasionally skin biopsy may be required to distinguish from other skin disorders such as psoriasis.

Other conditions which may result from contact with chemicals include:

  • Contact urticaria.
  • Acne, especially with oils, and folliculitis.
  • Skin infections with bacteria, fungi and viruses.
  • Pigmentary disorders.
  • Mechanical skin disease- damage from acute or repetitive trauma.
  • Skin cancer (mainly squamous cell carcinoma or basal cell carcinoma) may be more common than usually recognised. This can be due to UV radiation due to outside working, ionising radiation such as X-rays, lesions arising in scars following industrial burns or chemical carcinogens.[10]

General contact dermatitis treatment

The most effective form of management is to avoid the irritant producing the dermatitis, when this has been identified. The use of protective gloves with cotton liners or protective clothing may be helpful depending on the irritant and the environment.

Patients should be advised to wash their hands using products without perfume, and dry thoroughly afterwards. Rings should be removed, thoroughly cleaned and not worn again until the condition has resolved.

Avoidance of the irritant may be the only treatment required in milder cases of recent origin; the dermatitis will then resolve in a period of approximately three weeks.

Moisturisers used alone or in combination with barrier creams may result in a clinically important protective effect, either in the long- or short-term, for the primary prevention of occupational irritant hand dermatitis.[11]

Occupational dermatitis is notifiable to the HSE under the Reporting of Incidents, Diseases, and Dangerous Occurrences Regulations (RIDDOR). The employer has the responsibility for this, but the doctor treating has a responsibility to confirm the diagnosis and alert the employer. Those with significant disability from their condition should be directed to the Department for Work and Pensions (DWP) for assessment for industrial injuries disablement benefit.

Medication

More severe or chronic forms of dermatitis will benefit from the use of topical corticosteroid cream, the strength and period of use of the steroid being adjusted according to the severity of the condition. Occasionally a short course of an oral corticosteroid may be used for acute severe episodes. The use of antihistamines for itching is not advised by the National Institute for Health and Care Excellence (NICE).

Second-line agents (eg, psoralen combined with ultraviolet A (PUVA) treatment, ciclosporin and azathioprine) may be initiated in a specialist setting for the treatment of chronic, steroid-resistant dermatitis.

Secondary bacterial infection may occur, presenting either as worsening of the skin condition, or as typical impetigo.

Occupational skin disorders may have a considerable adverse impact on the quality of life.[12] They may also necessitate a change of occupation.

  • Usually, the condition will go with avoidance of the allergen but this may require giving up the job.
  • If the causative agents are easy to identify and avoid, contact dermatitis may resolve within a few weeks. However, if the causative allergens are difficult to avoid completely then contact dermatitis may be recurrent or persistent.
  • Sensitivity to some allergens may persist even after allergens are avoided - eg, epoxy resin, chromate, primin and paraphenylenediamine (commonly used in permanent hair dyes).
  • Allergic contact dermatitis has a worse prognosis than irritant contact dermatitis unless the allergen can be accurately identified and avoided.
  • Poor prognosis is also associated with severe dermatitis at presentation, and delay in diagnosis.

Employers have a duty to make the workplace as safe as possible. They may work in conjunction with trade union representatives to do so. They may seek help from the HSE or Control of Substances Hazardous to Health (COSHH). The HSE has a wealth of information on its website about prevention of occupational skin disease, including specific advice for specific occupations. General advice includes:[13]

  • Avoid direct contact between hands and substances. Stop wet work and use of irritant chemicals where possible. Introduce tools or equipment where possible to keep a barrier between skin and wet work/substances.
  • Protect skin where it is not possible to avoid contact:
    • Provide gloves and protective equipment (more specific advice on the gloves is available on the website).
    • Provide washing facilities - hot and cold water, cleaning creams, and suitable drying materials.
    • Advise workers on washing hands before and after eating, and before putting on gloves.
    • Wash off contamination promptly.
    • Advise workers to moisturise skin frequently.
  • Check hands regularly and seek advice early if problems are noted.
  • Educate employees.
  • Be aware of the health and safety hazards associated with each substance or product. There may be product labels or Safety Data Sheets.

Are you protected against flu?

See if you are eligible for a free NHS flu jab today.

Check now

Further reading and references

  • Jacobsen G, Rasmussen K, Bregnhoj A, et al; Causes of irritant contact dermatitis after occupational skin exposure: a systematic review. Int Arch Occup Environ Health. 2022 Jan95(1):35-65. doi: 10.1007/s00420-021-01781-0. Epub 2021 Oct 19.

  • Novak-Bilic G, Vucic M, Japundzic I, et al; Irritant and allergic contact dermatitis - skin lesion characteristics. Acta Clin Croat. 2018 Dec57(4):713-720. doi: 10.20471/acc.2018.57.04.13.

  • Larese Filon F, Pesce M, Paulo MS, et al; Incidence of occupational contact dermatitis in healthcare workers: a systematic review. J Eur Acad Dermatol Venereol. 2021 Jun35(6):1285-1289. doi: 10.1111/jdv.17096. Epub 2021 Feb 12.

  1. British Association of Dermatologists’ guidelines for the management of contact dermatitis 2017; British Association of Dermatologists (2017)

  2. Rubins A, Romanova A, Septe M, et al; Contact dermatitis: etiologies of the allergic and irritant type. Acta Dermatovenerol Alp Pannonica Adriat. 2020 Dec29(4):181-184.

  3. Houle MC, Holness DL, DeKoven J; Occupational Contact Dermatitis: An Individualized Approach to the Worker with Dermatitis. Curr Dermatol Rep. 202110(4):182-191. doi: 10.1007/s13671-021-00339-0. Epub 2021 Sep 14.

  4. Dermatitis - contact; NICE CKS, July 2018 (UK access only)

  5. Simonsen AB, Deleuran M, Johansen JD, et al; Contact allergy and allergic contact dermatitis in children - a review of current data. Contact Dermatitis. 2011 Nov65(5):254-65. doi: 10.1111/j.1600-0536.2011.01963.x. Epub 2011 Aug 18.

  6. Militello G, Jacob SE, Crawford GH; Allergic contact dermatitis in children. Curr Opin Pediatr. 2006 Aug18(4):385-90.

  7. Work-related skin disease; Health and Safety Executive (HSE)

  8. Smedley J; Concise guidance: diagnosis, management and prevention of occupational contact dermatitis. Clin Med. 2010 Oct10(5):487-90.

  9. Adisesh A, Robinson E, Nicholson PJ, et al; U.K. standards of care for occupational contact dermatitis and occupational contact urticaria. Br J Dermatol. 2013 Jun168(6):1167-75. doi: 10.1111/bjd.12256.

  10. Caroe TK, Ebbehoj NE, Wulf HC, et al; Occupational skin cancer may be underreported. Dan Med J. 2013 May60(5):A4624.

  11. Bauer A, Ronsch H, Elsner P, et al; Interventions for preventing occupational irritant hand dermatitis. Cochrane Database Syst Rev. 2018 Apr 304(4):CD004414. doi: 10.1002/14651858.CD004414.pub3.

  12. Lau MY, Matheson MC, Burgess JA, et al; Disease severity and quality of life in a follow-up study of patients with occupational contact dermatitis. Contact Dermatitis. 2011 Sep65(3):138-45. doi: 10.1111/j.1600-0536.2011.01896.x. Epub 2011 Jul 3.

  13. Skin at work - guidance; Health and Safety Executive (HSE)

newnav-downnewnav-up